Analisis Deskriptif Performa Instalasi Pengolahan Air Limbah (IPAL) Berdasarkan Parameter BOD, COD dan TSS pada Industri Pengalengan Bekicot

Della Lusiana Fitri; Firra Rosariawari; Aprilia Permata Sari

doi:10.61132/manufaktur.v3i2.831

Authors

Della Lusiana Fitri Universitas Pembangunan Nasional Veteran Jawa Timur
Firra Rosariawari Universitas Pembangunan Nasional Veteran Jawa Timur
Aprilia Permata Sari PT Alam Lestari Konsultan

DOI:

https://doi.org/10.61132/manufaktur.v3i2.831

Keywords:

BOD, COD, Snail canning industry, TSS, Wastewater

Abstract

The Snail Canning Industry has the potential to impact the environment if wastewater with high organic compound content is not treated first. This study aims to analyze the performance of the Snail Canning Industry Wastewater Treatment Plant (WWTP) based on BOD, COD, and TSS parameters. The method used is descriptive, with primary data obtained through interviews and secondary data from laboratory test results. Measurements were taken at the inlet and outlet points of the WWTP, then compared with the quality standards based on the Regulation of the Minister of Environment No. 5 of 2014. The results showed that the WWTP succeeded in reducing the concentration of BOD from 201 mg/L to 6 mg/L, COD from 315 mg/L to 24 mg/L, and TSS from 25 mg/L to 6 mg/L. The reduction efficiency of each parameter was 97.01% for BOD, 92.38% for COD, and 76% for TSS. All outlet results met the established quality standards. This indicates that the wastewater treatment process at the IPAL functions effectively in reducing the levels of pollutant parameters in wastewater.

References

Astuti, D., & Rosemalia, I. (2022). Review: Penurunan BOD (Biological Oxygen Demand) limbah cair domestik dengan fitoremediasi. Jurnal Unitek, 15(1), 59–72. https://doi.org/10.52072/unitek.v15i1.299

Fachria, R., Ramdan, H., & Aryantha, I. N. P. (2020). Efektivitas pengolahan limbah cair industri penyamakan kulit Sukaregang Garut dengan adsorben karbon aktif dan ijuk. Jurnal Pengelolaan Lingkungan Berkelanjutan (Journal of Environmental Sustainability Management), 3(3), 379–388. https://doi.org/10.36813/jplb.3.3.379-388

Fathoni, M., Pudjowati, U. R., & Sutikno. (2023). Perencanaan instalasi pengolahan air limbah (IPAL) domestik komunal di Dusun Sidomulyo Babakbawo Kabupaten Gresik. Maret, 4(1), 84–91.

Fatimah, N., Paramita, D. R. A., Rashati, D., & Siddiq, H. B. H. F. (2024). Analisa kadar sisa klor bebas menggunakan metode Mohr pada kolam renang di wilayah Kabupaten Jember. Jurnal Ilmiah Farmasi Akademisi Farmasi, 7(1), 29–35.

Faza, J., Purnama, S. I., & Syifa, F. T. (2021). Sistem monitoring tingkat pH, kekeruhan dan suhu air limbah batik pada instalasi pengolahan air limbah (IPAL) berbasis LoRa. Journal of Telecommunication, Electronics, and Control Engineering (JTECE), 3(1), 10–15. https://doi.org/10.20895/jtece.v3i1.146

Harahap, M. R., Amanda, L. D., & Matondang, A. H. (2020). Analisis kadar COD (Chemical Oxygen Demand) dan TSS (Total Suspended Solid) pada limbah cair dengan menggunakan spektrofotometer UV-Vis. Jurnal Amina, 2(2), 79–83.

Harvyandha, A., Kusumawardani, M., & Abdul, R. (2019). Telemetri pengukuran derajat keasaman secara real-time menggunakan Raspberry Pi. Jurnal Jartel, 9(4), 519–524.

Hermansyah, M. H., Putri, Y. P., Setiawan, A. A., Eddy, S., Jumingin, J., & Saputra, W. (2024). Uji padatan tersuspensi total (TSS) pada sampel air limbah sawit secara gravimetri. Environmental Science Journal (ESJO): Jurnal Ilmu Lingkungan, 2(2), 27–33. https://doi.org/10.31851/esjo.v2i2.15828

Ibrahim, R., Selintung, M., Zubair, A., Mangarengi, N. A. P., Abdullah, N. O., & Syarifuddin. (2023). Peningkatan kemampuan masyarakat dalam mengolah air limbah domestik melalui pelatihan pembuatan alat perangkap lemak (grease trap) sederhana. Jurnal TEPAT: Teknologi Terapan untuk Pengabdian Masyarakat, 6(1), 86–94.

Latifah, A. (2022). Pemeriksaan kualitas limbah cair dengan parameter amonia bebas (NH₃-N) dan fosfat (PO₄): Studi kasus Rumah Sakit Islam Ahmad Yani Surabaya. Human Care Journal, 7(3), 615–620.

Mulyati, S. A., Azizah, M., Srikandi, S., Maidaswar, M., & Atikah, N. (2022). The effectiveness of chlorine tablets to reducing coliform in wastewater treatment plant. Jurnal Sains Natural, 12(1), 10. https://doi.org/10.31938/jsn.v12i1.340

Setiadji, W., Effendi, N. R., Sutrisno, W., Mashadi, A., & Galuh, D. L. C. (2023). Efektivitas instalasi pengolahan air limbah berdasarkan parameter COD, BOD, TSS, pH (Studi kasus industri tahu di Dusun Janten Ngestiharjo Kasihan Bantul). Proceedings Series on Physical & Formal Sciences, 6, 28–36. https://doi.org/10.30595/pspfs.v6i.848

Ulvi, S. I., & Harmawan, T. (2022). Analisis kandungan minyak dan lemak pada limbah outlet pabrik kelapa sawit di Aceh Tamiang. Quimica: Jurnal Kimia Sains dan Terapan, 4(April), 15–19.

Wulandari, S., & Pramono, H. (2020). Processing of waste of canning and swimming crab (Portunus pelagicus) in PT. Sumber Mina Bahari Rembang, Central Java. Journal of Marine and Coastal Science, 7(2), 78. https://doi.org/10.20473/jmcs.v7i2.20716

Yuniarti, D. P., Komala, R., & Aziz, S. (2019). Pengaruh proses aerasi terhadap pengolahan limbah cair pabrik kelapa sawit di PTPN VII secara aerobik. Universitas PGRI Palembang, 4(2), 7–16.